\(1-<
- i
ADLN - PERPUSTAKAAN UNIVERSITAS AIRLANGGA
!'\ ft<
<
I5
10 )
A'f' C\ J
U
EKTRAKSI ION Ni(II) DBNGAN TEKNIK MEMBRAN
CAlK EMULSI MENGGUNAKAN ASAM STEARAT
SEBAGAI PENGOMPLEKS
SKRIPS)
ruRVSAN KIMIA
FAKULTAS MATEMATIICA DANB.MVPlNGETAHUAN ALAM
UNIVERSITAS AIRLANGGA
SURABAYA
2004
SKRIPSI
ADLN - PERPUSTAKAAN UNIVERSITAS AIRLANGGA
EIITRAKSI ION Ni(II) DENGAN TEKN1K MEMBRAN
CAIR EMULSI MENGGUNAKAN ASAM STEARAT
SEBAGAI PENGOMPLEKS
SKRIPSI
Sebagai Salab Saw Syarat Uatull MelDperoieb Gelar Sarja•• BidaDg Kimia Pada Fakultas Matematib daD Dm. PeRle""ua. Alam UDiversitJIs Airlangga
OIeh:
TRIAS ANGGRAINI
NIM : 089911994
Taaggal LaIn: 16 Jali lO84
Duetujui OIeh : Pembimhiag I :
Ora. Mirata' Khan.ala, M.Si NIP. 131 999 646
SKRIPSI
ADLN - PERPUSTAKAAN UNIVERSITAS AIRLANGGA
LEMBAR PENGESAHAN SKRIPSI
Judul
: Ektrabi loa Ni(U) delllan Teknik Membnn Cair Emulsi Menggu.akaa Asam Steant Sebapi Pe. . . .pleb
Penyusun
: Trias ADg&raiai
NIM
: 889911994
Pem bimbing I : Dra. Miratul Khatanah, M.Si Pembimbing n
: Drs. Bambaag Kurniadi, Apt Ditetujui Oleh :
Pembimbiag I
Dra. Miratul Khasanah, M.Si
NIP. 131 999 646
Meqetallai, Deun Fakultas MIPA Universitas Airlaagga,
Ketoa Jansa. Kimia FMIPA AirIa. . .,
Dn. T·
SKRIPSI
ADLN - PERPUSTAKAAN UNIVERSITAS AIRLANGGA
namoang r\.urluaUI • "'-In. dUI U~
" .....un.." ,....
_u.. . ._..............
~
ABSTI{AK
Telah dilakukan ckstraksi ion nikelC II) dengan teknik membran cair emulsi mengb'Unakan asam, stearat sebagai pengOl\lpleks, Fasa membran terdiri dan parafin cair sebagai pelarllt, asam stearat sebagai pengompieks, dan SPAN 80 sebagai surfaktan, Sedangkan fasa intemalnya berupa H2S04 1 M dan fasa ekstemalnya adalah lamtan iOIl Ni(Il), Ekstraksi ion Ni(lf) dilakukan dengan kondisi pcrbandingall volumc cmulsi dcngan nlsa ckSll:rnal 1:5 dengan kecepatan pengadukall skala 25 (1000 rpm) sdallla 10 I11cnit pm a pH 5,75, Emulsi dibuat dCllgan I11cm.:al1lpllrkan filsa inlcmal dcngan Iils(I IlH':lIlbran dengan perbandingan volumc 3:4, dan pcngadukall skala 60 (2400 rpm) sdama 7 men it. Penerapan kondisi optimum ckstraksi ion CU(") konscntrasi 50 ppm terhadap ekstraksi ion Ni(lI) dengan tcknik membran cair emulsi hanya dapat memberikan efisiensi ekstraksi scbesar 30,8:-: (~~, Sclalljutn:>a dcngan kondisi ini dilakukan ekstraksi iOIl Ni([l) dengan tcknik membrall cair CI11Uisl mcnggunakan varia~i konsentrasi 15 sampai 500 pplll. Nilai efisiensi ckslraksi dipcroleh antara 19,53 % sampai dengan 79,66 %.
Kata kunci . ekstraksi, ion nikel(ll), membran cair emulsi, asam stearat.
III
SKRIPSI
ADLN - PERPUSTAKAAN UNIVERSITAS AIRLANGGA
Trias Anggraini, 20()4. Extraction of Ni(lI) ion with emulsion liquid membrane technique containing sterk acid as coml1lexing agent. Final project was under guidence Dra. Miratul Khasanah M.Si and Drs. Bambang Kurniadi , Apt. Chemical departement, Mathematics and Natural Science Faculty Airlangga llniversity.
ABSTRACT
Extraction of nickel ion with emulsion liquid membrane technique containing steric acid as compexing agent has been studied. The membrane phase consist liquid paraffin as solvent, stearic acid as complexing agent, and SPAN 80 as surfactant. The internal phase was H2S04 1 M and the external phase using nickel ion solution. Extraction condition of nickel ion using the volume ratio of emulsion and external phase was 1:5 with scale or stirrer speed 25 (1000 rpm) in 10 minutes at pH 5,75. The emulsion was made by mixing the membrane phase and internal phase with ratio of 3:4 and stirrer speed scale 60 (2400 rpm) in 7 minutes. The condition used for the nickel ion extraction was adopted from the optimum condition of 50 ppm copper ion extraction. The extraction of 50 ppm nickel ion using this condition with emulsion liquid membrane technique only gave extraction efficiency about 30,88 %. This condition was then used to extraction of nickel ion with variation of concentration from 15 ppm to 500 ppm. Extraction efficiency value obtained from 19,53 % to 79,66 %. Base~ on this result, it can be concluded that the optimum condition of copper ion extraction cannot be used for nickel ion extraction with emulsion liquid membrane technique.
Key words: extraction, nickel ion, emulsion liquid membrane, stearic acid
IV
SKRIPSI